欣谕生产型冷冻干燥XY-GY-1000技术规格及配置
TECHNICAL SPECIFICATIONS
General Detail 总述 | |||
Sr. No. | Description 描述 | Specifications 规格 | |
1 | Mode 型号 | XY-GY-1000 | |
2 | Output (approx.) 产量（大约） | 1000KG | |
3 | Maximum ice capacity Z大捕冰力 | 1200kg | |
4 | Control 控制方式 | Microprocessor 微机处理 | |
5 | Dimension of unit (approx.) (L × W × H) (mm) 外型尺寸（大约）（长×宽×高） | 14500×2500×3500 (Final dimension based on design) （以Z终设计尺寸为准） | |
6 | Weight (approx.) 重量（大约） | 38,000kg | |
Chamber 冻干箱 | |||
1 | Chamber type 冻干箱外型 | Cylindrical 圆筒体 | |
2 | Maximum design pressure Z大设计压力 | 常压 | |
3 | Maximum design temperature Z大设计温度 | 常温 | |
4 | Finish 内部抛光度 | Ra≤0.5um (0.5Mircon) | |
5 | Validation port 验证孔 | Included 有（1个）位置箱体顶部 | |
6 | Viewing port 视镜 | Illuminated 带远射灯【广角】 | |
Number 数量 | 1 | ||
Location 位置 | Side 侧面 | ||
Dimension 尺寸 | DN200 (mm) | ||
7 | Material 材质 | ||
Internal 内部 | SUS 304 | ||
Insulation 保温 | polyisocyanurate foam 聚氨酯发泡材料 | ||
External cover 外部 | SUS 304 | ||
Door 箱门 | |||
1 | Finish 抛光度 | Ra≤0.5um (0.5Mircon) | |
2 | Viewing port 视镜 | Included 有 | |
Number 数量 | 1 | ||
Location 位置 | On height 1.5m (approx.) 高度1.5米（大约） | ||
3 | Open direction 开门方向(根据客户要求） | Right (face to door, hinge on right side) 右开（面对箱门，铰链在右） | |
4 | Open angle 开门角度 | More than 110o 大于110度 | |
5 | Gasket 密封圈 | O-shaped silicone rubber single gasket O型硅橡胶单密封 | |
6 | Locking arrangement 门锁方式 | Auxiliary manual handle 辅助手柄 | |
7 | Material 材质 | ||
Internal 内部 | SUS 304 | ||
Insulation 保温 | polyisocyanurate foam 聚氨酯发泡材料 | ||
External cover 外部 | 304 | ||
Shelves 板层 | |||
1 | Temperature range 温度范围 | -45~-50°C to + 80°C | |
2 | Temperature sensors (shelves) 板层温度探头 | 3 | |
Silicone oil inlet 导热油进口 | |||
Silicone oil outlet 导热油出口 | |||
3 | sensors 温度探头 | 3 | |
4 | Number of shelves 板层数 | 16+ 1(upper radiant shelf) （温度补偿板） | |
5 | Dimension (L × W × T) (mm) 板层尺寸（以设计为准） | 4000x1600x15 | |
6 | area (sq. m) 面积 | 102 | |
7 | Spacing (mm) 板间距 | 65 | |
8 | Hose of flexible connection 软管连接 | Welding 焊接 | |
9 | Finish 抛光度 | Ra≤0.5um (0.5Micron) | |
10 | Level 平整度 | ≤±0.5mm/m | |
11 | Material 材质 | SUS 304 | |
Condenser 冷凝器 | |||
1 | Condenser type 冷凝器外型 | Cylindrical 圆筒体 | |
2 | Viewing port 视镜 | Illuminated 带远射灯【广角】 | |
Number 数量 | 1 | ||
Location 位置 | Easily observe the whole inside condenser 容易观察到整个箱体内部 | ||
Dimension 尺寸 | DN200 (mm) | ||
3 | Final temperature J限温度 | -65°C~-70℃ | |
4 | Cooling time (+20 to -40°C) 制冷速度(空载) | ≤30 minutes (empty) | |
5 | Maximum design pressure Z大设计压力 | 常压 | |
6 | Maximum design temperature Z大设计温度 | 常温 | |
7 | Finish 抛光度 | Ra≤0.5um (0.5Mircon) | |
8 | Coiled pipe material 盘管材质 | SUS 304 | |
Internal 内部 | SUS 304 | ||
Insulation 保温 | polyisocyanurate foam 聚氨酯发泡材料 | ||
External cover 外部 | SUS 304 | ||
Shelf Heating / Cooling 板层升温/降温 | |||
1 | Circulation pump 循环泵 | ||
Brand 品牌 | DF | ||
Model 型号 | CDL65-1 | ||
Type 形式 | Centrifugal pump 离心式 | ||
Number 数量 | 1 | ||
Motor power 电机功率 | 5.5kW | ||
2 | Plate heat exchanger 板式热交换器 | ||
Brand 品牌 | Hexnovo | ||
Type 方式 | Sealed brazed stainless steel 不锈钢封蜂窝式 | ||
Number 数量 | 1 | ||
3 | Heater 电加热 | PID control PID 控制【双组电加热系统】 | |
4 | Maximum heating power Z大加热功率 | 24KW*4 | |
5 | Thermal fluid 导热介质 | Special heat conducting oil for freeze dryer 冻干机专用导热油 | |
6 | Shelf cooling time (+20°C to -40°C) 板层制冷速度(空载) | ≤60 minutes (empty) | |
7 | Heating rate 加热速度(大约) | 1°C/min (approx.) | |
Refrigerating System 制冷系统 | |||
1 | Compressor 压缩机 | ||
Brand 品牌 | RefComp 莱富康（意大利） | ||
Model 型号 | SW3L10500 | ||
Type 方式 | Two-stage 双级 | ||
Number 数量 | 2 | ||
Motor power 电机功率 | 78kW *2 | ||
2 | Refrigerant 制冷剂 | HFC-free R404A | |
Main refrigerating units 主要制冷元件 | |||
1 | Thermostatic expansion valve 热力膨胀阀 | Danfoss | |
2 | Solenoid valve 电磁阀 | Danfoss | |
3 | Service valve关断阀 | Denaline | |
4 | Safety valve安全阀 | Castel | |
5 | Capped valve顶盖阀 | Castel | |
6 | Sight glass视液镜 | Danfoss | |
7 | Water cooling condenser水冷凝器 | Teyi | |
8 | Oil separator 油分离器 | Fasike | |
9 | Gas-liquid separator 汽液分离器 | Fasike | |
10 | Filter 过滤器 | 滤壳Hongguo滤芯 ALCO | |
Vacuum System 真空系统 | |||
1 | Final vacuum J限真空 | ≤2.7×10 -2mbar | |
2 | Evacuation time 抽气速度 | ≤30minutes (1×103 mbar to 1×10-1 mbar) | |
3 | Vacuum pump 真空泵 | ||
Brand 品牌 | Baosi | ||
Model 型号 | BSV90 | ||
Type 方式 | OIL-rotary 油旋片式真空泵 | ||
Number 数量 | 6 | ||
Flow rate 排气速度 | 90m3/hr (×6) | ||
Motor power 电机功率 | 3.7Kw (×3) | ||
5 | Mechanical booster pump 罗茨泵 | ||
Brand 品牌 | BAOSI | ||
Model 型号 | BSJ300L | ||
Type 方式 | Roots 机械式 | ||
Number 数量 | 1 | ||
Flow rate 抽气速度 | 1000m3/hr (×2) | ||
Motor power 电机功率 | 3.7KW (×2) | ||
6 | Anti-suction valve 真空防倒吸阀 | Included 有 | |
Control System 控制系统 | |||
1 | Software 软件 | 欣谕-5000（可随时免费升级） | |
Automatic 自动 | Included 有 | ||
Manual 手动 | Included 有 | ||
2 | PLC+PC 可编程控制器 | Omron | |
3 | Industrial personal Computer 工控机 | 品牌平板电脑 | |
4 | Vacuum gauge 真空探头 | ZHVAC | |
5 | Temperature probe 温度探头 | Pt100 | |
6 | Pressure transducer 压力变送器 | GK | |
7 | Breaker 空开 | schneider | |
8 | Contactor 接触器 | schneider | |
9
| Relay 继电器 | schneider | |
Safety System 安全系统 | |||
1 | Vacuum failure protection 真空失败保护 | Included 有 | |
2 | Temperature failure protection 温度失败保护 | Included 有 | |
3 | Compressor protection 压缩机保护 | Included 有 | |
4 | Other motors protection 其它电机保护 | Included 有 | |
5 | Interlock protection 连锁保护 | Included 有 | |
Utility Requirement (approx.) 公用工程消耗(大约) | |||
1 | Electricity - total electrical load 总装机功率 | 270kW (380V, 50Hz, 3Phase, 5Wire) | |
2 | Cooling water for refrigerant cooling 用于制冷系统的冷却水 | 60m3/hr (1.5≤P≤2bar, T≤25°C) | |
